Measurements of formaldehyde and TVOC emission from paints and coating materials using small chamber method for building composites
作者： Jin-A. Kim , Sumin Kim , Hyun-Joong Kim , Janghoo Seo
DOI: 10.1007/S11595-012-0420-8
关键词: Materials science 、 Cell volume 、 Emulsion 、 Coating 、 Composite material 、 Coating materials 、 Curing (chemistry) 、 Optimal test 、 Formaldehyde 、 Chamber method
摘要: An optimal test method for paint is proposed; additionally, the Field and Laboratory Emission Cell (FLEC) used in Europe applied as a substitute 20 L small chamber method. The emission factors of total volatile organic compounds (TVOC) formaldehyde from oil-based paint, emulsion water-dispersion with coating weight 300 g/m2, cured 24/48 hours, were measured using rate TVOC all paints began to stabilize after approximately 7 days hours curing even though Korean standards stipulate that should be analyzed third day application. factor oil-based, emulsion, also FLEC There was good correlation between emissions. With method, prepared under identical conditions, stable 24 installation samples because air flow much higher than chamber, relative cell volume smaller chamber.
springer.com
elsevier.com
sci-hub.se 参考文章(17)
Sumin Kim, Hyun-Joong Kim, Jin-A Kim, Application of Field and Laboratory Emission Cell (FLEC) to Determine Formaldehyde and VOCs Emissions from Wood-Based Composites* 1 Journal of the Korean wood science and technology. ,vol. 35, pp. 24- 37 ,(2007)
Stephen K. Brown, Occurrence of Volatile Organic Compounds in Indoor Air Organic Indoor Air Pollutants: Occurrence - Measurement - Evaluation. pp. 170- 184 ,(2007) , 10.1002/9783527613663.CH13
Edmone Roffael, Volatile organic compounds and formaldehyde in nature, wood and wood based panels European Journal of Wood and Wood Products. ,vol. 64, pp. 144- 149 ,(2006) , 10.1007/S00107-005-0061-0
Marja Tuomainen, Anna-Liisa Pasanen, Anneli Tuomainen, Jyrki Liesivuori, Pirjo Juvonen, Usefulness of the Finnish classification of indoor climate, construction and finishing materials: comparison of indoor climate between two new blocks of flats in Finland Atmospheric Environment. ,vol. 35, pp. 305- 313 ,(2001) , 10.1016/S1352-2310(00)00157-6
Sumin Kim, Jin-A Kim, Jae-Yoon AN, Hyun-Joong Kim, Suck-Joong Moon, Development of a test method using a VOC analyzer to measure VOC emission from adhesives for building materials Journal of Adhesion Science and Technology. ,vol. 20, pp. 1783- 1799 ,(2006) , 10.1163/156856106779024445
Sumin Kim, Hyun-Joong Kim, Comparison of standard methods and gas chromatography method in determination of formaldehyde emission from MDF bonded with formaldehyde-based resins. Bioresource Technology. ,vol. 96, pp. 1457- 1464 ,(2005) , 10.1016/J.BIORTECH.2004.12.003
Gökay Nemli, Gürsel Çolakogˇlu, The influence of lamination technique on the properties of particleboard Building and Environment. ,vol. 40, pp. 83- 87 ,(2005) , 10.1016/J.BUILDENV.2004.05.007
Sumin Kim, Hyun-Joong Kim, Effect of addition of polyvinyl acetate to melamine-formaldehyde resin on the adhesion and formaldehyde emission in engineered flooring International Journal of Adhesion and Adhesives. ,vol. 25, pp. 456- 461 ,(2005) , 10.1016/J.IJADHADH.2005.01.001
Rika Funaki, Shin-ichi Tanabe, Chemical Emission Rates from Building Materials Measured by a Small Chamber Journal of Asian Architecture and Building Engineering. ,vol. 1, pp. 93- 100 ,(2002) , 10.3130/JAABE.1.2_93
Sumin Kim, Jin-A. Kim, Jae-Yoon An, Hyun-Joong Kim, Shin Do Kim, Jin Chul Park, TVOC and formaldehyde emission behaviors from flooring materials bonded with environmental-friendly MF/PVAc hybrid resins Indoor Air. ,vol. 17, pp. 404- 415 ,(2007) , 10.1111/J.1600-0668.2007.00488.X