Thermodynamic performance of a low temperature multi-effect distillation experimental unit with horizontal-tube falling film evaporation
作者： Luopeng Yang , Shengqiang Shen , Huawei Hu
关键词: Distillation 、 Evaporation 、 Vacuum distillation 、 Evaporator 、 Chemistry 、 Experimental system 、 Multiple-effect distillation 、 Seawater 、 Volumetric flow rate 、 Thermodynamics
摘要: A five-effect distillation experimental unit was designed and fabricated the thermodynamic performance measured evaluated. The mechanical design process operation parameters of a low temperature multi-effect were optimized. This nit featured horizontal-tube falling film evaporation. Its achieved maintained, its heat loss effectively reduced. variation pressure in each evaporator effect tested ana lyzed. results indicated that calculated vacuum evaporating coincided. Water production rate gained output ratio (GOR) decreased slightly with an increase flow feed seawater. With heating steam water linearly increased GOR increased. found to be fairly close observation, which justified expectation analytical model developed for distiller reliable, overall system correctly done.
deswater.com
sci-hub.se 参考文章(11)
M.M. Shah, A general correlation for heat transfer during film condensation inside pipes International Journal of Heat and Mass Transfer. ,vol. 22, pp. 547- 556 ,(1979) , 10.1016/0017-9310(79)90058-9
Hisham T. El-Dessouky, Hisham M. Ettouney, Faisal Mandani, Performance of parallel feed multiple effect evaporation system for seawater desalination Applied Thermal Engineering. ,vol. 20, pp. 1679- 1706 ,(2000) , 10.1016/S1359-4311(99)00098-8
J.-F. Roques, J. R. Thome, Falling Films on Arrays of Horizontal Tubes with R-134a, Part II: Flow Visualization, Onset of Dryout, and Heat Transfer Predictions Heat Transfer Engineering. ,vol. 28, pp. 415- 434 ,(2007) , 10.1080/01457630601163736
Gherhardt Ribatski, Anthony M. Jacobi, Falling-film evaporation on horizontal tubes—a critical review International Journal of Refrigeration. ,vol. 28, pp. 635- 653 ,(2005) , 10.1016/J.IJREFRIG.2004.12.002
J. F. Roques, V. Dupont, J. R. Thome, Falling Film Transitions on Plain and Enhanced Tubes Journal of Heat Transfer-transactions of The Asme. ,vol. 124, pp. 491- 499 ,(2002) , 10.1115/1.1458017
Jechin Han, Leroy S. Fletcher, Falling film evaporation and boiling in circumferential and axial grooves on horizontal tubes Industrial & Engineering Chemistry Process Design and Development. ,vol. 24, pp. 570- 575 ,(1985) , 10.1021/I200030A009
X. Zeng, M.-C. Chyu, Z.H. Ayub, Experimental investigation on ammonia spray evaporator with triangular-pitch plain-tube bundle, Part I: tube bundle effect International Journal of Heat and Mass Transfer. ,vol. 44, pp. 2299- 2310 ,(2001) , 10.1016/S0017-9310(00)00250-7
Hisham T. El-Dessouky, H.M. Ettouney, Multiple-effect evaporation desalination systems. thermal analysis Desalination. ,vol. 125, pp. 259- 276 ,(1999) , 10.1016/S0011-9164(99)00147-2
Gherhardt Ribatski, John R. Thome, Experimental study on the onset of local dryout in an evaporating falling film on horizontal plain tubes Experimental Thermal and Fluid Science. ,vol. 31, pp. 483- 493 ,(2007) , 10.1016/J.EXPTHERMFLUSCI.2006.05.010
Yang Luo-peng, Thermal analysis of low temperature seawater multi-effect distillation system Chemical Engineering. ,(2006)