Performance Evaluation of a Horizontal Air Staged Inclined Biomass-to-Heat Energy Converter for Drying Paper Egg Trays
作者： Kok Hing Chong , Puong Ling Law , Rigit Andrew Ragai Henry , Baini Rubiyah , FARIDAH SALEH Shanti
DOI:
关键词:
摘要: This study presents the performance evaluation of a horizontal air staged inclined biomass-to-heat energy (B2H) converter used for drying purposes in production paper egg-trays. The thermal properties and moisture content selected biomass such as oil palm kernel shell wood chips were assessed. influence mixture ratio (AMR) on temperature profile, flue gases composition combustion efficiency determined with Testo 350XL gas analyser. It was observed that an increase AMR led to average pyrolytic chamber but decreased exhaust, insignificant change surrounding temperature. CO, H 2 , NO x SO concentrations inversely proportional oxygen B2H exhaust. Combustion AMR. 67.00 0.34 % achieved Experiment vii. CO emissions at exhaust (Experiment-vii) met EPA regulations, is, 193.35 9.17 ppmv 9.20 0.87 ppmv, respectively. emission however, lower than NIOSH 4.57 1.08 ppmv. Thus demonstrated can be significantly reduced chips.
参考文章(53)
C. Leuenberger, W. Giger, R. Coney, J.W. Graydon, E. Molnar-Kubica, Persistent chemicals in pulp mill effluents: Occurrence and behaviour in an activated sludge treatment plant Water Research. ,vol. 19, pp. 885- 894 ,(1985) , 10.1016/0043-1354(85)90147-2
A.P.C. Faaij, Energy from biomass and waste ,(1997)
Mohamad Shaiful Ashrul Ishak, Mohammad Nazri Mohd Jaafar, B Blok, Kompleks Pusat Pengajian Jejawi, NOXIOUS EMISSION REDUCTION FROM LIQUID FUEL BURNER VIA AIR STAGING METHOD Jurnal Mekanikal. ,vol. 24, ,(2007)
L. Baxter, B. Jenkins, F. Winter, Baseline NO{sub x} emissions during combustion of wood-derived pyrolysis oils ,(1995) , 10.2172/10111897
Jan Sandberg, Ulf Sand, Rebei Bel Fdhila, Ulf Sand, Measurements, theories and simulations of particle deposits on super-heater tubes in a CFB biomass boiler International Journal of Green Energy. ,vol. 3, pp. 43- 61 ,(2006) , 10.1080/01971520500439492
Erik Fløjgaard Kristensen, Jens Kristian Kristensen, Development and test of small-scale batch-fired straw boilers in Denmark. Biomass & Bioenergy. ,vol. 26, pp. 561- 569 ,(2004) , 10.1016/J.BIOMBIOE.2003.09.006
Juan F. Pérez, Andrés Melgar, Pedro Nel Benjumea, Effect of operating and design parameters on the gasification/combustion process of waste biomass in fixed bed downdraft reactors: An experimental study Fuel. ,vol. 96, pp. 487- 496 ,(2012) , 10.1016/J.FUEL.2012.01.064
J.G Brammer, A.V Bridgwater, Drying technologies for an integrated gasification bio-energy plant Renewable and Sustainable Energy Reviews. ,vol. 3, pp. 243- 289 ,(1999) , 10.1016/S1364-0321(99)00008-8