Optimization of Fluidized Bed Reactor of Oxidative Coupling of Methane
作者： Mohammad-Hosein Eghbal-Ahmadi , Masoud Zaerpour , Mahdi Daneshpayeh , Navid Mostoufi
关键词:
摘要: Optimization of process variables in the oxidative coupling methane (OCM) over Mn/Na2WO4/SiO2 catalyst a fluidized bed reactor was carried out. Effects operating temperature, distribution pattern oxygen injected to and number injections on performance C2 (ethane + ethylene) yield were investigated. Process for one, two three secondary investigated obtain maximum by genetic algorithm optimization method. The selectivity 47.1% 22.87%, respectively, achieved at temperature 746.05◦C. this study is approximately 4% better than previous works reported literature while optimum lower.
researchgate.net 
sci-hub.se 参考文章(31)
Stanislav Jašo, Harvey Arellano-Garcia, Günter Wozny, Oxidative coupling of methane in a fluidized bed reactor: Influence of feeding policy, hydrodynamics, and reactor geometry Chemical Engineering Journal. ,vol. 171, pp. 255- 271 ,(2011) , 10.1016/J.CEJ.2011.03.077
D.J. Wang, M.P. Rosynek, J.H. Lunsford, Oxidative Coupling of Methane over Oxide-Supported Sodium-Manganese Catalysts Journal of Catalysis. ,vol. 155, pp. 390- 402 ,(1995) , 10.1006/JCAT.1995.1221
L. Mleczko, M. Baerns, Catalytic oxidative coupling of methane—reaction engineering aspects and process schemes Fuel Processing Technology. ,vol. 42, pp. 217- 248 ,(1995) , 10.1016/0378-3820(94)00121-9
R Sotudeh-Gharebagh, Jamal Chaouki, P Sauriol, None, An experimental study of non-premixed combustion in a turbulent fluidized-bed reactor Fuel Processing Technology. ,vol. 88, pp. 847- 858 ,(2007) , 10.1016/J.FUPROC.2007.04.009
Heping Cui, Navid Mostoufi, Jamal Chaouki, None, Characterization of dynamic gas–solid distribution in fluidized beds Chemical Engineering Journal. ,vol. 79, pp. 133- 143 ,(2000) , 10.1016/S1385-8947(00)00178-9
Maryam Sadi, Bahram Dabir, Abbas Shahrabadi, Multiobjective optimization of polymerization reaction of vinyl acetate by genetic algorithm technique with a new replacement criterion Polymer Engineering & Science. ,vol. 48, pp. 853- 859 ,(2008) , 10.1002/PEN.21020
Fahad Al‐Sherehy, John Grace, Alaa‐Eldin Adris, None, Gas Mixing and Modeling of Secondary Gas Distribution in a Bench-Scale Fluidized Bed Aiche Journal. ,vol. 50, pp. 922- 936 ,(2004) , 10.1002/AIC.10090
S. Mori, C. Y. Wen, Estimation of bubble diameter in gaseous fluidized beds Aiche Journal. ,vol. 21, pp. 109- 115 ,(1975) , 10.1002/AIC.690210114
R. Andorf, L. Mleczko, D. Schweer, M. Baerns, Oxidative coupling of methane in a bubbling fluidized bed reactor Canadian Journal of Chemical Engineering. ,vol. 69, pp. 891- 897 ,(1991) , 10.1002/CJCE.5450690411
Yu Liu, Ruiling Hou, Xuxia Liu, Jinzhen Xue, Shuben Li, Performance of Na2WO4-Mn/SiO2 catalyst for conversion of CH4 with CO2 into C2 hydrocarbons and its mechanism Studies in Surface Science and Catalysis. ,vol. 119, pp. 307- 311 ,(1998) , 10.1016/S0167-2991(98)80449-7